State Series 301 Uživatelský manuál

Procházejte online nebo si stáhněte Uživatelský manuál pro Bojler State Series 301. State Series 301 User Manual Uživatelská příručka

  • Stažení
  • Přidat do mých příruček
  • Tisk
  • Strana
    / 40
  • Tabulka s obsahem
  • ŘEŠENÍ PROBLÉMŮ
  • KNIHY
  • Hodnocené. / 5. Na základě hodnocení zákazníků
Zobrazit stránku 0
1
This water heater complies with ANSI Z21.10.1-current
edition regarding the accidental or unintended ignition of
ammable vapors, such as those emitted by gasoline.
For Your Safety
AN ODORANT IS ADDED TO THE GAS USED
BY THIS WATER HEATER.
• Safety Instructions
• Installation
• Operation
FVIR
GAS WATER HEATER
(FLAMMABLE VAPOR IGNITION RESISTANT)
FOR SPACE HEATING AND POTABLE WATER HEATING ONLY.
NOT FOR USE IN MOBILE HOMES.
PRINTED IN THE U.S.A. 1013 PART NO. 320388-003
ALL TECHNICAL AND WARRANTY QUESTIONS: SHOULD BE DIRECTED TO THE LOCAL DEALER FROM WHOM THE WATER HEATER WAS PURCHASED.
IF YOU ARE UNSUCCESSFUL, CONTACT RESIDENTIAL TECHNICAL ASSISTANCE AT 1-800-365-0024 OR WWW.STATEWATERHEATERS.COM.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.
Do not touch any electrical switch;
do not use any phone in your
building.
Immediately call your gas supplier
from a neighbors phone. Follow the
gas suppliers instructions.
If you cannot reach your gas
supplier, call the fire department.
Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, personal injury or death.
RESIDENTIAL GAS WATER HEATERS
Installation Instructions and Use & Care Guide
INSTALLER:
AFFIX THESE INSTRUCTIONS TO OR ADJACENT
TO THE WATER HEATER.
OWNER:
RETAIN THESE INSTRUCTIONS AND WARRANTY
FOR FUTURE REFERENCE. RETAIN THE
ORIGINAL RECEIPT AS PROOF OF PURCHASE.
WARNING: Gas leaks can not always be detected by
smell.
Gas suppliers recommend that you use a gas detector
approved by UL or CSA.
For more information, contact the your gas supplier.
If a gas leak is detected, follow the “WHAT TO DO IF YOU
SMELL GAS” instructions.
Care and Maintenance
• Troubleshooting
• Parts List
LOW LEAD
C
O
NTENT
Zobrazit stránku 0
1 2 3 4 5 6 ... 39 40

Shrnutí obsahu

Strany 1 - GAS WATER HEATER

1This water heater complies with ANSI Z21.10.1-current edition regarding the accidental or unintended ignition of fl ammable vapors, such as those emit

Strany 2 - TABLE OF CONTENTS

10LP Gas Only WARNINGExplosion HazardHave a qualified technician make sure that the

Strany 3 - FIRE AND EXPLOSION HAZARD

11TABLE 3BTUH InputMinimum SquareFeet with8’ CeilingTypical Roomwith 8’ Ceiling30,000 188 9 x 2145,000 281 14 x 2060,000 375 15 x 2575,000 469 15 x 31

Strany 4 - Fire or Explosion Harzard

1212” MAXIMUMPERMANENTOPENINGS TOTHE OUTSIDE OR ADDITIONAL ROOMS WITHINTHE BUILDINGCLOSETOR OTHER CONFINED SPACE12” MAXIMUMFIGURE 4.All Air from Insid

Strany 5 - TYPICAL INSTALLATION

13ALTERNATIVEOPENINGLOCATION1 SQ. INCH PER 3000 BTUHCONFINEDSPACEALL AIR FROM OUTDOORS - USING A SINGLE PERMANENT OPENINGFIGURE 8B.Vent Pipe System

Strany 6 - Excessive Weight Hazard

14Align the legs of the draft hood with the slots provided. Insert the legs and secure the draft hood to the water heater’s top with the four screws p

Strany 7 - FLAMMABLES

15Piping Installation Piping, fittings, and valves should be installed according to the installation

Strany 8 - FIGURE 2

16METALDRAIN PAN1 3/4” DEPTH MAXIMUMFLOOR DRAINDRAIN LINE 3/4” ID MINIMUMDISCHARGE PIPEDO NOT CAP OR PLUGTEMPERATURE AND PRESSURE RELIEF VALVEIN A CLO

Strany 9

17• Must not be capped, blocked, plugged or contain any valve between the relief valve and the end of the dis-charge line.• Must terminate a maximum

Strany 10 - Explosion Hazard

18• Be sure to follow the manual(s) shipped with the air handler system.• This water heater is not to be used as a replacement for an existing boile

Strany 11 - Carbon Monoxide Warning

19IMPORTANT INFORMATION ABOUT THIS WATER HEATERThis gas water heater was manufactured to voluntary safety standards to reduce the likelihood of a flam

Strany 12

2TABLE OF CONTENTSWater Heater Safety ...

Strany 13 - FIGURE 8A

20WARNINGExplosion HazardReplace view port if glass is missingor damaged.Failure to do so can result in death,explosion or fire.Lighting Instructions

Strany 14 - FIGURE 10

21FOR YOUR SAFETY READ BEFORE LIGHTINGWARNING: FLAMMABLE If you do not follow these instructions exactly, afire or explosion may result causing proper

Strany 15 - TYPE B DOUBLE WALL VENT PIPE

22Water Temperature Regulation Water temperature over 125°F (52°C) can cause servere burns instantly resulting in se

Strany 16 - FIGURE 14

23Water Temperature °FTime for 1st Degree Burn (Less Severe Burns)Time for Permanent Burns 2nd & 3rd Degree (Most Severe Burns)1101161161221311401

Strany 17 - Explosion Harzard

244. The ignition of flammable vapors.A thermopile is used to determine if a pilot flame is present, and will shut off the gas supply to the main bur

Strany 18 - FIGURE 16

25The following are typical (but not all) signs of a depleted anode rod:• The majority of the rods diameter is less than 3/8”.• Significant sections

Strany 19 - Company

26TEMPERATURE AND PRESSURERELIEF VALVEDISCHARGE LINE TO DRAINMANUAL RELIEFVALVEFIGURE 21.6. Use needle nose pliers to disconnect the white (-) thermo

Strany 20 - OPERATING YOUR WATER HEATER

27Replacing the Pilot/ Thermopile Assembly 1. Remove the manifold door assembly as described in “Remov

Strany 21 - TO TURN OFF GAS TO APPLIANCE

28External Inspection & Cleaning of the Base-Ring Filter 1. At least once annually, c

Strany 22 - Burn Hazard

297. Connect the white (-) thermopile wire to the gas control valve/thermostat, then connect the red thermal switch wires to the thermal switch on th

Strany 23 - FIGURE 19B

3SAFE INSTALLATION, USE AND SERVICEYour safety and the safety of others is extremely important in the installation, use and servicing of this water he

Strany 24

30FVIR System Operational Checklist 1. Manifold gasket properly sealed.2. Viewport not damaged or cracked.3. Flam

Strany 25

31PROBLEM POSSIBLE CAUSE(S) CORRECTIVE ACTIONSLOW HOT WATER RECOVERY1. Insufficient combustion air2. Water heater flue or vent system blocked3. Low

Strany 26 - MANUAL RELIEF

32PILOT LIGHT TROUBLESHOOTING FLOWCHARTHave you bled all the air from the pilot tube and gas supply line?NOWhile repeatedly depressing the igniter but

Strany 27 - FIGURE 27

33LED STATUS PROBLEM CORRECTIVE ACTION0 FLASHES (LED NOT LIT) Pilot light is not lit or Thermopile has not yet reached normal operating temperature.Tu

Strany 28

34STATUS LIGHT AND DIAGNOSTIC CODE TROUBLESHOOTING CHART (Continued)LED STATUS PROBLEM CORRECTIVE ACTION4 FLASHES The Gas Control Valve’s temperature

Strany 30 - TROUBLESHOOTING CHART

36REPAIR PARTS ILLUSTRATION25146879103When ordering repair parts, always give the following information:1. Model, serial, and product number2. Type

Strany 31

37Listed Parts Kits and Illustrations

Strany 32 - FIGURE 31

38THIS WARRANTY IS APPLICABLE TO THE ORIGINAL OWNER ONLY, in accordance with the warranty terms and conditions specified below.State Water Heaters (th

Strany 33 - NOTE: This gas control

39LIMITATION ON IMPLIED WARRANTIESImplied warranties, including any warranty of merchantability imposed on the sale of this heater under state law are

Strany 34

4Fire or Explosion HarzardDo not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance. Avoid all

Strany 35

40Copyright © 2013 State Industries, Inc. All rights reserved.

Strany 36 - REPAIR PARTS ILLUSTRATION

5TYPICAL INSTALLATIONGET TO KNOW YOUR WATER HEATER - GAS MODELS A Vent Pipe B Draft Hood C Anode (Not Shown) D Hot Water Outlet E Insulation F

Strany 37

6INSTALLING YOUR GAS WATER HEATERImportant Information About This Water Heater This gas water heater was manufactured to voluntary safety standa

Strany 38

7Location Requirements Carbon Monoxide Poisoning HazardWARNINGDo not install in a mobile home. Doing so

Strany 39

8IMPORTANT: The water heater should be located in an area where leakage of the tank or connections will not result in damage to the area adjacent to t

Strany 40

9Manual GasShut-off ValveGroundJointUnionSediment Trap3” MinimumCheck with localutility forminimum height6” MaximumAir GapFIGURE 3.Gas Pressure

Příbuzné modely Series 300

Komentáře k této Příručce

Žádné komentáře